Fuse box diagram (fuse layout), location and also assignment that fuses and also relays Ford expedition (1997, 1998, 1999, 2000, 2001, 2002).

You are watching: 2002 ford expedition owners manual fuse box


Checking and also Replacing Fuses

Fuses and also circuit breakers safeguard your vehicle’s electrical system from overloading. If electric parts in your auto are not working, the mechanism may have actually been overloaded and also blown a fuse or tripped a circuit breaker. Before you change or repair any kind of electrical parts, inspect the ideal fuses or circuit breakers.

To check a fuse, look at the silver-colored band inside the fuse. If the tape is broken or melted, replace the fuse.


Before replacing fuses inspect that the vital has been gotten rid of from the ignition and that every the solutions are switched off and/or disengaged.Always disconnect the battery before servicing high current fuses.Always change a fuse v one that has actually the specified amperage rating. Utilizing a fuse v a higher amperage rating can reason severe cable damage and also could begin a fire.Never change a damaged fuse through anything other than a new fuse. Use always an intact fuse that the same color.If a fuse blows again call a qualified organization center.

Passenger Compartment Fuse crate Diagram

The fuse panel is located below and also to the left the the steering wheel through the brake pedal. Pull the panel cover outside to accessibility the fuses. To eliminate a fuse usage the fuse puller tool provided on the fuse panel cover.



25Overhead expedition Computer,
Electronic automatic Temperature regulate (EATC),
Powertrain regulate Module (PCM),
320Cigar Lighter,
OBD-II Scan device Connector
47.5Remote entry Module,
Memory attributes (Seats and also Pedals)
515Speed manage Module,
Reverse Lamp,
EVO Module,
Climate mode Switch (Front Blower Relay),
Daytime running Lamp Relay,
Reverse Sensing System,
E/C Mirror
Overhead pilgrimage Computer,
Brake change Interlock Solenoid,
Air Suspension Module,
GEM Module,
EVO Steering Sensor,
Heated Mirror,
Rear Defroster,
Reverse Sensing System
75Aux A/C Blower Relay (via fuse 22)
Remote entrance Module,
GEM Module
9-Not Used
10-Not Used
1130Front Washer Pump Relay,
Wiper Run/Park Relay,
Wiper Hi/LO Relay,
Windshield Wiper Motor,
Rear Washer Pump Relay
1215Air Suspension Switch
1320Stop Lamp switch (Lamps),
Turn/Hazard Flasher,
Speed regulate Module
1415Rear Wipers,
Running board Lamps,
Battery Saver Relay,
Interior lamp Relay,
Accessory hold-up Relay (Power Windows, Moonroof, upper and lower reversal Windows)
155Stop lamp Switch, (Speed Control, Brake change Interlock, ABS, PCM Module Inputs, air Suspension Module, Autolock),
GEM Module
1620Headlamps (Hi Beams),
Cluster (Hi Beam Indicator)
1710Heated Mirrors,
Heated Grid move Indicator
185Instrument Illumination (Dimmer switch Power)
19-Not Used
Air Suspension Module,
GEM Module,
Memory Module
2115Starter Relay,
Fuse 20,
Transmission selection Switch
2210Air Bag Module,
Climate mode Switch (Blower Relay),
EATC Blower Relay,
Feeds Fuse 7
2310Aux A/C,
Heated Seats,
Trailer Tow Battery Charge,
Turn/Hazard Flasher,
4x4 Clutch Relay,
Overhead Console,
E/C Mirror,
4 Wheel Anti-Lock Brake system (4WABS) Module
24-Not Used
25-Not Used
2610Right Side short Beam Headlamp
275Foglamp Relay and Foglamp Indicator
2810Left Side short Beam Headlamp
295Autolamp Module,
Transmission Overdrive control Switch
3030Passive Anti Theft Transceiver, Cluster, Ignition Coils, Powertrain regulate Module Relay
3110Rear integrated Control panel (Audio),
CD Player
Relay 1-Interior desk lamp Relay
Relay 2-Battery Saver Relay
Relay 3-Rear window Defroster Relay
Relay 4-One Touch Down home window Relay
Relay 5-ACC hold-up Relay

Engine Compartment Fuse Box

The power distribution box is located in the engine compartment. The power distribution box contains high-current fuses that safeguard your vehicle’s main electrical systems indigenous overloads.

Diagram (Version 1)


120Trailer tow back-up & tail lamps
210Airbag diagnostic monitor
330Power locks
415Air suspension
630Engine minifuse box fuses #3 and #5
715Park and also tail lamps
915Fog lamps and also DRL
1025Auxiliary instrument panel (I/P) power point
1125Auxiliary console strength point
1210Rear wiper
1330Auxiliary blower
1460Four wheel anti-lock brake system (4WABS)
1550Air suspension compressor
1640Trailer tow battery charge, engine minifuse box fuse #2, engine minifuse crate fuse #4
1730Four-wheel journey (4WD) transfer instance motor and also clutch
1830Driver power sea
1920Fuel pump
2050Junction crate ignition switched feed
2150Junction box ignition switched feed
2250Junction crate battery feed
2340Front blower
2430Powertrain control module power
2530 C.B.Windows
26-not used
2740Heated backlite and also mirrors
2830Trailer tow electric brake
2930Hybrid fan, moon roof, upper and lower reversal windows
1-not used
2-PCM diode
1-Windshield wipers high/low speed
2-Windshield wipers run/park
3-Front washer pump relay
4-Fuel pump relay
5-Horn relay
6-PCM strength relay

Diagram (Version 2)



120Power Point
230Powertrain manage Module
420Console Powerpoint
520Trailer Tow Backup/Park Lamps
615Parklamps/Autolamps, Feeds Passenger Compartment Fuse 18
830Power Door Locks
915Daytime to run Lamps (DRL), Fog Lamps
1020Fuel Pump
1120Alternator Field
1210Rear Wipers
1315A/C Clutch
14-Not Used
1510Running board Lamps
16-Not Used
1710Flip Windows
1815Powertrain regulate Module, Fuel Injectors, Fuel Pump, fixed Air flow Sensor
1910Trailer Tow Stop and also Right revolve Lamp
2010Trailer Tow Stop and Left turn Lamp
21-Not Used
22-Not Used
2315HEGO Sensors, Canister Vent, automatic Transmission, CMS Sensor
24-Not Used
10130Trailer Tow Battery Charge
10250Four Wheel Antilock Brake Module
10350Junction Block Battery Feed
104304x4 shift Motor & Clutch
10540Climate control Front Blower
106-Not Used
107-Not Used
10830Trailer Tow electrical Brake
10950Air Suspension Compressor
11030Heated Seats
11140Ignition move Battery feed (Run/Start Circuit)
11230Drivers strength Seat, flexible Pedals, storage Module
11340Ignition switch Battery feeding (Run and Accessory Circuits)
11430Climate regulate Auxiliary Blower
115-Not Used
11640Rear home window Defroster, boil Mirrors
117-Not Used
118-Not Used
201-Trailer Tow Park desk lamp Relay
202-Front Wiper Run/Park Relay
203-Trailer Tow back-up Lamp Relay
204-A/C Clutch Relay
205-Rear Wiper Down
206-Foglamp Relay
207-Front Washer Pump Relay
208-Rear Washer Pump Relay
209-Rear Wiper Up
301-Fuel Pump Relay
302-Trailer Tow Battery fee Relay
303-Wiper Hi/Lo Relay
304-Powertrain regulate Module Relay
401-Not Used
501-Powertrain manage Module Diode
502-A/C Clutch Diode
503-Not Used
60130Delayed Accessory (Power Windows, upper and lower reversal Windows, Moonroof)
602-Not Used

Primary battery fuses (megafuses)

The major battery fuses are situated in the engine compartment close to the battery. Ford recommends the a qualified company technician service the mega fuses.


1175Power network box megause
2175Alternator megafuse
320Alternator ar minifuse
Engine mini fuse box

The engine mini fuses are situated on the driver’s next of the engine compartment.


15Powertrain manage module (PCM)
220Trailer tow stop/turn lamps
310Audio rear incorporated control panel (RICP), compact key changer, radio
410Running board lamps
520Amplifier, subwoofer amplifier
6-Not Used

This website offers cookies to boost your experience. We"ll assume you"re ok v this, however you have the right to opt-out if friend wish. Cookie settingsACCEPT
Privacy & cookie Policy

Privacy Overview
This website offers cookies to boost your endure while friend navigate with the website. Out of this cookies, the cookies that are categorized as crucial are save on computer on your internet browser as lock are crucial for the working of simple functionalities the the website. We also use third-party cookies that help us analyze and understand how you usage this website. This cookies will be save on computer in your web browser only v your consent. You also have the choice to opt-out of this cookies. However opting out of some of these cookies may have actually an result on your looking experience.
Necessary cookies room absolutely vital for the website to duty properly. This category only consists of cookies that ensures basic functionalities and security attributes of the website. This cookies execute not store any personal information.

See more: Has Anyone Won Mvp As A Rookie Of The Year And Mvp In The Nba?

Any cookies that might not be an especially necessary because that the website to function and is provided specifically to collection user personal data via analytics, ads, other embedded materials are termed as non-necessary cookies. That is mandatory come procure user consent before running these cookie on her website.